A Boeing 727 begins an uncommanded roll to the right, along with loss of hydraulic fluid, which almost resulted in the loss of the aircraft. Investigators recreate all the steps of the flight, to solve the mystery.
TWA Flight 841 was a scheduled passenger flight from John F. Kennedy International Airport in New York City, en route to Minneapolis-Saint Paul International Airport in Minneapolis, Minnesota. On April 4, 1979, at or around 9:48 p.m. Eastern Standard Time (01:48 UTC), while flying over Saginaw, Michigan, the Boeing 727-31 airliner began a sharp, uncommanded roll to the right, and subsequently went into a spiral dive. The pilots were able to regain control of the aircraft and made a successful emergency landing at Detroit Metropolitan Airport.
.jpg)
Incident
At 8:25 p.m. EST, TWA Flight 841 departed JFK International after a 45-minute delay due to traffic congestion and reached its initial cruising altitude of 35,000 feet at 8:54 p.m. Due to a 100-knot headwind, the pilots requested to climb to 39,000 feet at 9:25 p.m., which was granted. At 9:49 p.m., after traveling nearly 540 miles (870 km),[2] while cruising at 39,000 feet (12,000 m) near the city of Saginaw, Michigan, Captain Harvey "Hoot" Gibson (44), (1934-2015),[3] says the aircraft was operating with the autopilot on "Altitude Hold" mode when he felt a light buffeting of the airframe. He saw the plane banking right and the autopilot moving the control wheel to the left to level the wings. This had no effect so Gibson disconnected the autopilot and applied full left aileron which had no effect. He got on the rudder pedals to apply full left rudder. He would state that as he did so he felt something didn't feel right with the rudder but didn't know what it was. Captain Gibson's inputs had no effect as the plane very quickly began a steep roll to the right. Gibson shouted "Get em' up!" referring to the co-pilot to deploy the speed brakes, but the co-pilot didn't understand what the Captain meant so Gibson deployed them. Despite the best efforts of the flight crew, the aircraft spiraled out of control; Gibson shouted, "We're going over!". Flight 841 dived about 34,000 feet (10,000 m) in just 63 seconds.During the course of the dive, the plane rolled through 360 degrees twice and exceeded the Mach limit for the 727 airframe. During the dive, Captain Gibson got so desperate to save the plane that he began moving his control column from all the way left to all the way right, then all the way forward and all the way back, but his efforts were fruitless.
At about 15,000 feet (4,600 m) the pilots extended the landing gear in an attempt to slow the aircraft. A few seconds after extending the gear, Captain Gibson managed to regain control and pull the 727 out of its dive, and at about 5,000 feet (1,500 m) the nose finally came up again.The plane suffered substantial structural damage with the System A hydraulics ruptured as a result of the right main landing gear overextending but made an emergency landing at Detroit Metropolitan Airport in Michigan at 10:31 p.m. EST without further trouble. No fatalities occurred among the 82 passengers and 7 crew members. Eight passengers reported minor injuries related to high g-forces.
Investigation
The National Transportation Safety Board (NTSB) investigated the accident, conducting what was at the time the lengthiest accident investigation in NTSB history.[6] In its final report, published in June 1981, the NTSB concluded the probable cause of the accident was a mechanical failure of a leading-edge slat under inappropriate manipulation and the captain's untimely action.
Among the damage discovered after the accident, investigators found the #7 slat missing from the leading edge of the right wing. NTSB investigators requested the aircraft manufacturer, Boeing, inspect the remainder of the slat assembly, including a portion of the slat actuator cylinder (the motor that moves the slat and holds it in position). Boeing determined that the #7 slat had failed because the slats had been extended while the aircraft was flying at cruising speed. They also determined that it was "impossible" for the flaps to extend without manipulating the controls.
After eliminating all individual and combined sources of mechanical failure, the NTSB ruled that the extension of the slats was due to the flight crew manipulating the flap/slat controls in an inappropriate manner. Investigators believed that 727 pilots (in general, and this flight specifically) were setting the trailing edge flaps to two degrees during high altitude cruise, while at the same time pulling the circuit breaker for the slats so that they would not activate. This configuration was rumored to result in increased lift with no increase in drag, thus allowing more speed, higher elevation, or decreased fuel consumption. Flaps and slats were intended to only be deployed at low speeds during take-off or landing.
The crew, Capt. Harvey G. "Hoot" Gibson, first officer J. Scott Kennedy (1939-2017),[9] and flight engineer Gary N. Banks, denied that their actions had been the cause of the flaps' extension
At no time prior to the incident did I take any action within the cockpit either intentionally or inadvertently, that would have caused the extension of the leading edge slats or trailing edge flaps. Nor did I observe any other crew member take any action within the cockpit, either intentional or inadvertent, which would have caused the extension.
— Capt. Gibson
The crew suggested instead that an actuator on the #7 slat had failed, causing its inadvertent deployment. The NTSB rejected this as improbable and attributed the extension of the flaps to the deliberate actions of the crew. The crew claimed that such failures had happened on other 727s prior and subsequent to this incident. The NTSB report noted that between 1970 and 1973, seven separate cases involving a single leading edge slat extension and separation were reported, but none of these reports indicated whether or not the slat extension was due to flight crew involvement.Records after 1974 did include this information, and (other than Flight 174) only two slat extension problems were reported between 1974 and the close of the NTSB's investigation in 1981, one of which was inadvertently caused by the flight crew.
The flight crew testified that they had not engaged the flaps, and the NTSB concluded that "if the flightcrew's recollections are accurate," the slat extension must have been caused by a mechanical failure or defect. However, the NTSB ultimately concluded that the flight crew was probably attempting to use 2º of flaps at cruising speed:
While cruising at Mach 0.816 and 39,000 feet pressure altitude and with the autopilot controlling the aircraft, an attempt was made to extend 2º of trailing edge flaps independently of the leading edge slats, probably in an effort to improve aircraft performance.
When retraction of the flaps was ordered, the Number 7 leading edge slat failed to retract, causing the uncommanded roll to the right.
The Safety Board determines that the probable cause of this accident was the isolation of the No. 7 leading edge slat in the fully or partially extended position after an extension of the Nos. 2, 3, 6 and 7 leading edge slats and the subsequent retraction of the Nos. 2, 3, and 6 slats, and the captain's untimely flight control inputs to counter the roll resulting from the slat asymmetry. Contributing to the cause was a preexisting misalignment of the No. 7 slat which, when combined with the cruise condition airloads, precluded retraction of that slat. After eliminating all probable individual or combined mechanical failures, or malfunctions which could lead to slat extension, the Safety Board determined that the extension of the slats was the result of the flightcrew's manipulation of the flap/slat controls. Contributing to the captain's untimely use of the flight controls was distraction due probably to his efforts to rectify the source of the control problem.
Gibson appealed against the NTSB's findings, first to the NTSB itself and then to the U.S. Ninth Circuit Court of Appeals. Both petitions were rejected: the former for lack of new evidence, and the latter for lack of jurisdiction due to the NTSB's "unreviewable discretion".
The aircraft was repaired and returned to service in May 1979.
Cockpit voice recorder
The aircraft was equipped with a Fairchild Industries Model A-100 cockpit voice recorder (CVR). However, 21 minutes of the 30-minute tape were blank. tests of the CVR in the aircraft revealed no discrepancies in the CVR's electrical and recording systems.The CVR tape can be erased by means of the bulk-erase feature on the CVR control panel located in the cockpit. This feature can be activated only after the aircraft is on the ground with its parking brake engaged.In a deposition taken by the Safety Board, the captain stated that he usually activates the bulk-erase feature on the CVR at the conclusion of each flight to preclude inappropriate use of recorded conversations. However, in this instance, he could not recall having done so. The NTSB made the following statement in the accident report:
We believe the captain's erasure of the CVR is a factor we cannot ignore and cannot sanction. Although we recognize that habits can cause actions not desired or intended by the actor, we have difficulty accepting the fact that the captain's putative habit of routinely erasing the CVR after each flight was not restrainable after a flight in which disaster was only narrowly averted. Our skepticism persists even though the CVR would not have contained any contemporaneous information about the events that immediately preceded the loss of control because we believe it probable that the 25 minutes or more of recording which preceded the landing at Detroit could have provided clues about causal factors and might have served to refresh the flightcrew's memories about the whole matter.
Criticism of investigation
In the book Emergency: Crisis In the Cockpit,Stanley Stewart, a professional pilot, has raised questions about the NTSB findings:
Stewart suggests that the crew would not have been able to erase the CVR as the aircraft had to be completely shut down and on the ground. According to Stewart, the damage should have meant that the computers did not recognize the aircraft in a fully landed state (page 217).
He suggests that there were other incidents of 727-200s with uncommanded slat extensions in the years prior to and after the accident
The flight crew knew the aircraft was potentially unstable at 39,000 ft. Stewart believes it would be unlikely they would "fool around" with the controls and risk the stability of the aircraft
Tags:
air crash investigation season 22
mayday air crash investigation season 22
air crash investigation season 22 pacific plunge
reddit air crash investigation season 22
air crash investigation season 22 episode 5 reddit
air crash investigation season 22 episode 6 reddit
air crash investigation season 22 episode 9 reddit
air crash investigation season 22 episode 1 reddit
air crash investigation season 22 episode 7 reddit
air crash investigation season 22 episode 8 reddit
air crash investigation season 22 reddit links
air crash investigation season 22 reddit
top 10 air crash investigation episodes
air crash investigation season 22 online free
air crash investigation season 22 tree strike terror
air crash investigation season 22 episode 2 watch online
air crash investigation season 22 episode 1 watch online
air crash investigation season 22 peril over portugal
air crash investigation season 22 online
mayday air crash investigation season 22 reddit
air crash investigation season 22 terror over michigan
air crash investigation season 22 reddit link
air crash investigation season 22 list of episodes
air crash investigation season 22 links
air crash investigations season 21
air crash investigation season 21 episodes
air crash investigation season 22 stream
stream air crash investigation season 22
air crash investigation season 22 imdb
air crash investigation season 21 episode 3
air crash investigation season 22 episode 2 dailymotion
air crash investigation season 22 episode 11
air crash investigation season 22 123movies
air crash investigation season 21 episode 5
air crash investigation season 22 03
air crash investigation season 22 022
air crash investigation season 22 0123
air crash investigation season 22 01
air crash investigation season 22 0123movies
air crash investigation season 21 episode 10
watch air crash investigation season 22 online
air crash investigation season 22 turboprop terror
watch air crash investigation series 22
air crash investigation season 22 wiki
air crash investigation season 22 vietsub
air crash investigation season 22 voice actors
air crash investigation season 22 video
air crash investigation series 22 uk
air crash investigation season 22 uk
where to watch air crash investigation season 22
air crash investigation season 22 youtube
air crash investigation season 22 where to watch
air crash investigation season 22 twitter
air crash investigation season 21 caught in a jam
air crash investigation season 22 holding pattern
watch air crash investigation season 22
best episodes of air crash investigation
air crash investigation season 22 episode 9 bilibili
air crash investigation season 22 episode 8 bilibili
air crash investigation season 22 episode 4 bilibili
air crash investigation season 22 episode 3 bilibili
air crash investigation season 22 episode 2 bilibili
air crash investigation season 22 kobe bryant
air crash investigation season 22 stealth bomber down
air crash investigation season 22 pitch black
air crash investigation season 22 bilibili
air crash investigation timing
air crash investigation season 21 release date
bilibili air crash investigation season 22
air crash investigation season 22 uk air date
air crash investigation season 22 loss of a legend
air crash investigation season 22 australia
air crash investigation season 22 episode 6
air crash investigation season 22 episode 9
air crash investigation season 22 episode 7
air crash investigation season 22 episode 2
air crash investigation season 22 episode 10
air crash investigation season 22 episode 1
air crash investigation season 22 episode 4
air crash investigation season 22 episode 5
air crash investigation season 22 episode 5 bilibili
where can i watch air crash investigation season 22
national geographic air crash investigation season 22
air crash investigation season 22 episode 3
air crash investigation season 22 national geographic
air crash investigation season 22 episode 1 watch online free
air crash investigation season 22 episode 1 full episode
air crash investigation season 22 episode 1 facebook
air crash investigation season 22 watch online free
air crash investigation season 22 flydubai
air crash investigation season 22 free
air crash investigation season 22 full episodes
air crash investigation season 22 facebook
air crash investigation season 22 episodes
air crash investigation season 22 episode 8
air crash investigation season 22 episode 5 dailymotion
best air crash investigation
air crash investigation season 22 episode 9 dailymotion
dailymotion air crash investigation season 22
air crash investigation season 22 episode 1 dailymotion
mayday air crash investigation season 22 dailymotion
air crash investigation season 22 release date uk
air crash investigation season 22 release date
air crash investigation season 22 disney plus
air crash investigation season 22 double trouble
air crash investigation season 22 dvd
air crash investigation season 22 download
air crash investigation season 22 dailymotion
which flights crashed on 911